INSTALLATION GUIDE FOR DRY FUEL MODELS: (GM DRIVEN, DRY FUEL GEN-SETS) SP-200 SP-250 SP-300 SP-410 SP-520 SP-620 SP-800 SP-1000 SP-1250 SP-1400 GILL
PAGE 10 can be ignited. Leaks in fuel system can be ignited. Both are conditions that can cause fire and/or explosion, leading to pos
PAGE 11 ● Starting battery is not included. See page 17 for battery supply information. ● All gen-sets have the required vibration i
PAGE 12 1) Always install your generator within 20 feet from natural gas meter or LPV vapor withdrawal tank. Further distances may cause “starvin
PAGE 13 WARNING: An open bottom, stationary gen-set must be installed over a non-combustible material, such as a cement slab, and must
PAGE 14 TYPICAL EMERGENCY GENERATOR INSTALLATION PRACTICES FOR “OPEN” (NON-SELF ENCLOSED) GENERATOR A standby emergency power systems will give year
PAGE 15 It is, however, available as an option purchase. GILLETTE does not offer the “Industrial” grade muffler as it is very loud and
PAGE 16 F) The exhaust piping system is subject to engine vibration, so it must be solidly installed to reduce potential for pipe cr
PAGE 17 circulate into the radiator core. Thermostat can also close, restricting the coolant flow, as necessary to prevent over cooling. The
PAGE 18 TYPICAL OPTIONAL EQUIPMENT THAT MAY BE INSTALLED ON YOUR GENERATOR A) Flexible Fuel Line: This is a requirement in most local cod
PAGE 19 1) “Standard” housing with standard interior sound deadening foam and mounted residential grade muffler. 2) “Super-Silent” housin
PAGE 2 TABLE OF CONTENTS Page Introduction, General Cautions, Warnings, Danger & Danger Points ------- 3-10 Recei
PAGE 20 Cu. Ft., under column 11-20 Ft. runs = 470 Cu. Ft. Locate the required pipe diameter at left side of Table C = 1” Dia. TABLE A: ENGINE HO
PAGE 21 Propane (LPV) and natural gas (NG) is extremely flammable and explosive. Fire or explosion can cause serious burns or death. LPV
PAGE 22 All new installations, plus any future repair or troubleshooting procedures must include a natural gas manometer test. Thi
PAGE 23 LPV fuel pressure must be 6 ounce pressure (11-12 inches water column) delivered to the generator. Often new LPV tanks o
PAGE 24 cables. Place the selected fully charged battery with full electrolyte in battery tray and secure with battery hold down strap. Before
PAGE 25 ● Contact with battery acid will cause severe burns to the skin and eyes. A battery can cause an electrical shock. Before wor
PAGE 26 for Buyer to know, that all ATS operating methods, parts supplied, operational services, warranties, etc. are the responsibilities
PAGE 27 OIL DRAIN: Remove oil drain hose from the holding clip. Remove the end cap from end of oil drain hose, and let oil drain into a separa
PAGE 28 TERMINAL CONNECTOR TORQUE Use the torque values shown for terminal connectors. Refer to UL-486A, UL-486B, and UL-486E for informatio
PAGE 29 FORMULAS THAT MAY BE OF USE TEMPERATURE ºC = (ºF – 32) x 0.55555 ºF = (ºC X 1.8) + 32 VELOCITY ft/sec x 0.3048 = m/sec
PAGE 3 PRODUCT SAFETY INFORMATION SECTION 1 SAFETY RESPONSIBILITY Be sure that you are completely familiar with the safe operation of this equip
GILLETTE GENERATORS AUTOMATIC POWER SYSTEMS OGU06-OWN-795-20120824 Gillette Generators, Inc. 1340 Wade Drive Elkhart, IN 46514 Phone: 574-264-9639 Fax
PAGE 4 use by non-qualified operator can cause serious or fatal injury. DANGER: Disconnect all electrical wires and load devices from gener
PAGE 5 death. Symptoms of carbon monoxide poising include: dizziness, nausea, headaches, sleepiness, vomiting, or incoherence. If an
PAGE 6 with the National Electrical Code and local regulations. WARNING: Parts of this generator are extremely hot during and after operation
PAGE 7 This gen-set may have an all weather protected metal enclosure, MADE EXCLUSIVELY FOR OUTDOOR INSTALLATION, and will operate on its specifi
PAGE 8 ● Generator should not be exposed to excessive and constant moisture, dust, dirt, or corrosive environments. ● If connected loads cau
PAGE 9 generator. Jewelry will conduct electricity, causing electric shock. ● If generator must be serviced while it is running, st
Kommentare zu diesen Handbüchern